Thickening supercritical CO2 at high temperatures with rod-like reverse micelles

Azmi Mohamed

Abstract

Earlier studies demonstrated the ability of some fluorinated surfactants to form rod-like reverse micelles with the ability to thicken water/supercritical CO2 (scCO2) mixtures at temperatures below 45 ºC [Langmuir 26 (2010) 83–88. Soft Matter 8 (2012) 7044–7055. Colloids and Surfaces B, 168 (2018), 201–210.]. Such viscosity enhancement of scCO2 is known to increase sweep efficiency for oil recovery with CO2 flooding. However, temperatures of up to ∼100 ºC in conventional reservoirs are much higher than those employed in laboratory studies, and tend to weaken inter- and intra-molecular interactions between surfactant molecules, discouraging rod-like reverse micelle formation. With the aim of designing surfactants which form rod-like reverse micelles and thicken CO2 at high temperatures, this study examined phase behavior, nanostructures of reverse micelles and thickening ability of double ω-hydroperfluorocarbon-tail anionic surfactants in W/scCO2 mixtures at temperatures of 35 - 75 ºC and pressure of 80 - 400 bar with different water-to-surfactant molar ratios (W0). The measured CO2 viscosity increased by 1.9–2.2 × for double-chain surfactants M(di-HCF6)x (counterion Mx+ = Ni2+ and Co2+) at 40 mM, over the experimental temperature range. On the other hand, the shorter chain H(CF2)4CH2 twin-tail surfactants M(di-HCF4)x and Na(di-HCF6) gave only 1.1–1.5 × viscosity enhancements. The maximum thickening ability of M(di-HCF6)2 was at W0 = 10 in the W0 range of 5–20 75 ºC and 350 bar. High pressure and high temperature small-angle neutron scattering (SANS) was used determine the micellar structure in these systems, and rod micelles of aspect ratios of 4.5–6.5 were found. The results clearly suggest that ω-hydroperfluorohexyl-tails and divalent counterions induce the formation of rod-like reverse micelles in W/CO2 mixtures, even at high temperatures commensurate with in-reservoir conditions. © 2024 Elsevier B.V.

References

E.J. Beckman, Supercritical and near-critical CO2 in green chemical synthesis and processing, J. Supercrit. Fluids 28 (2004) 121-191.

O. Massarweh, A. S. Abushaikha, A review of recent developments in CO2 mobility control in enhanced oil recovery, Petroleum, 8 (2022) 291-317.

S. Cummings, R. Enick, S. Rogers, R. Heenan, J. Eastoe, Amphiphiles for supercritical CO2, Biochimie 94 (2012) 94-100.

K.A. Consani, R.D. Smith, Observations on the solubility of surfactants and related molecules in carbon dioxide at 50 ºC, J. Supercrit. Fluids 3 (1990) 51-65.

E.L.V. Goetheer, M.A.G. Vortaman, J.T.F. Keurentjes, Opportunities for process intensification using reverse micelles in liquid and supercritical carbon dioxide, Chem. Eng. Sci. 54 (1999) 1589-1596.

W. Ryoo, S.E. Webber, K.P. Johnston, Water-in-carbon dioxide microemulsions with methylated branched hydrocarbon surfactants, Ind. Eng. Chem. Res. 42 (2003) 6348-6358.

H. Lee, J.W. Pack, W. Wang, K.J. Thurecht, S.M. Howdle, Synthesis and phase behavior of CO2- soluble hydrocarbon copolymer: poly(Vinyl Acetate-alt-Dibutyl Maleate), Macromolecules 43 (2010) 2276-2282.

M. Sagisaka, K. Kudo, S. Nagoya, A. Yoshizawa, Highly methyl-branched hydrocarbon surfactant as a CO2-philic solubilizer for water/supercritical CO2 microemulsion, J. Oleo Sci. 62 (2013) 481-488.

J. Eastoe, A. Mohamed, K. Trickett, S.Y. Chin, S. Cummings, M. Sagisaka, L. Hudson, S. Nave, R. Dyer, S. Rogers, R. Heenan, A universal surfactant for water, oils and CO2, Langmuir 26 (2010) 1386113866.

M. Zulauf, H.F. Eicke, Inverted micelles and microemulsions in the ternary system 644 water/aerosol- OT/isooctane as studied by photon correlation spectroscopy, J. Phys. Chem. 83 (1979) 480 486.

C.T. Jr. Lee, P.A. Psathas, K.P. Johnston, J. deGrazia, T.W. Randolph, Water-in-carbon dioxide emulsions: formation and stability, Langmuir 15 (1999) 6781-6791.

K.P. Johnston, K.L. Harrison, M.J. Klarke, S.M. Howdle, M.P. Heitz, F.V. Bright, C. Carlier, T.W. Randolph, Water-in-carbon dioxide microemulsions: a new environment for hydrophiles including proteins, Science 271 (1996) 624-626.

R.G. Zielinski, S.R. Kline, E.W. Kaler, N.A. Rosov, Small-angle neutron scattering study of water in carbon dioxide microemulsions, Langmuir 13 (1997) 3934-3937.

E.D. Niemeyer, F.V. Bright, The pH within PFPE reverse micelles formed in supercritical CO2, J. Phys. Chem. B 102 (1998) 1474-1478.

V.H. Dalvi, V. Srinivasan, P.J. Rossky, Understanding the effectiveness of fluorocarbon ligands in dispersing nanoparticles in supercritical carbon dioxide, J. Phys. Chem. C 114 (2010) 15553-15561.

V.H. Dalvi, V. Srinivasan, P.J. Rossky, Understanding the relative effectiveness of alkanethiol ligands in dispersing nanoparticles in supercritical carbon dioxide and ethane, J. Phys. Chem. C 114 (2010) 15562-15573.

M. Sagisaka, S. Iwama, A. Yoshizawa, A. Mohamed, S. Cummings, J. Eastoe, Effective and Efficient Surfactant for CO2 Having Only Short Fluorocarbon Chains, Langmuir 28 (2012) 10988-10996.

M. Sagisaka, S. Yoda, Y. Takebayashi, K. Otake, B. Kitiyanan, Y. Kondo, N. Yoshino, K. Takebayashi, H. Sakai, M. Abe, Preparation of a W/scCO2 microemulsion using fluorinated surfactants, Langmuir, 19 (2003) 220-225.